How many recalls does the Toyota RAV4 have?

As of NHTSA records retrieved 2026-08-27, NHTSA lists 19 recall campaigns for the Toyota RAV4, model years 2016–2024. A recall applies to specific VIN ranges, variants, trims or build dates, so a particular vehicle may be affected by all, some, or none of them, and a campaign count is not a reliability ranking. Whether an open recall is a safety risk depends on the campaign, so read the NHTSA entry for the VIN. Each campaign below shows the remedy NHTSA records, which may be a dealer or service-center repair, an over-the-air software update, or, for some campaigns, a repurchase. This page details the most recent campaigns; the full record for any VIN is at nhtsa.gov/recalls.

What should an inspector check on a used Toyota RAV4?

Beyond the standard pre-purchase checks, the recall history for this model concentrates in: tires, equipment, air bags, service brakes, electrical system, back over prevention. An inspector documents the visible and operational condition of those systems without disassembly; internal parts, software-only issues and whether a recall remedy was performed are VIN-lookup questions, not inspection findings.

Can a pre-purchase inspection tell me whether a Toyota RAV4 recall was done?

No. Whether a recall repair was performed is recorded against the VIN, so NHTSA's lookup at nhtsa.gov/recalls (or the manufacturer's own) is the authoritative check. Run it before you travel. The inspection covers what a VIN lookup cannot: the physical condition of the vehicle in front of you.

Can you inspect a Toyota RAV4 at a dealer, a private seller, or out of state?

Yes. The inspector usually travels to the vehicle at the seller's location — a dealer lot or a private seller — and you do not need to be there. Vehicle Inspectors dispatches an independent inspector within 50 miles of any US ZIP code, widening to 150 miles if needed; more remote locations are quoted case by case. You get a photo-documented PDF report in 24–48 hours.

How much does a Toyota RAV4 pre-purchase inspection cost?

A pre-purchase inspection of a Toyota RAV4 through Vehicle Inspectors: Bronze $249 · Silver $349 · Gold $449. Your card is saved at booking, not charged. A hold is placed when an inspector schedules, and you are charged after the inspection is completed. If no inspector accepts within 72 hours, the request auto-cancels and nothing is charged.

Should You Buy a Used Toyota RAV4?

Showing the 12 most recent of 19 campaigns, newest first, from NHTSA records. Check a specific VIN at nhtsa.gov/recalls. The Toyota RAV4 recall guide walks through the recent campaigns by system and what each means for a used buyer.

25V744000NHTSA report received October 2025Model years: 2023–2024

NHTSA campaign 25V744000: Toyota RAV4 back over prevention recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence: A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy per NHTSA (as of 2026-08-27): Dealers will update the parking assist software, free of charge.

25V595000NHTSA report received September 2025Model years: 2023–2024

NHTSA campaign 25V595000: Toyota RAV4 electrical system recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.

Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Remedy per NHTSA (as of 2026-08-27): Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge.

24V911000NHTSA report received December 2024Model years: 2024

NHTSA campaign 24V911000: Toyota RAV4 service brakes recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024 RAV4 and 2025 Lexus NX vehicles. Some of the bolts that secure the front brake caliper and the wheel hub bearing may be loose, which can result in a damaged caliper brake hose or possible wheel detachment.

Consequence: A damaged brake line can cause a brake fluid leak, reducing brake performance and increasing the distance required to stop the vehicle. Wheel detachment can result in a loss of vehicle control. Either condition increases the risk of a crash.

Remedy per NHTSA (as of 2026-08-27): Dealers will inspect and tighten the front brake caliper mounting bracket and hub bearing bolts, as necessary, free of charge.

23V865000NHTSA report received December 2023Model years: 2020–2021

NHTSA campaign 23V865000: Toyota RAV4 air bags recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.

Consequence: An air bag that does not deploy during a crash increases the risk of injury.

Remedy per NHTSA (as of 2026-08-27): Dealers will inspect and replace the sensor as necessary, free of charge.

23V734000NHTSA report received November 2023Model years: 2016–2018

NHTSA campaign 23V734000: Toyota RAV4 electrical system recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.

Consequence: A battery short circuit increases the risk of a fire.

Remedy per NHTSA (as of 2026-08-27): Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge.

23V485000NHTSA report received July 2023Model years: 2023

NHTSA campaign 23V485000: Toyota RAV4 tires recall

Gulf States Toyota, Inc. (GST) is recalling certain 2023 Toyota RAV4 vehicles equipped with 17" black alloy accessory wheels. During installation of the alloy wheels, the tire valve stem may have been improperly installed or damaged. In addition, the load carrying capacity label may state the incorrect weight. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence: A damaged or improperly installed valve stem may allow air to leak and/or the tires to be underinflated, increasing the risk of tire failure and a crash.

Remedy per NHTSA (as of 2026-08-27): Dealers will inspect and, if necessary, replace the wheel valve stems and replace the load carrying capacity modification labels, free of charge.

22V519000NHTSA report received July 2022Model years: 2022

NHTSA campaign 22V519000: Toyota RAV4 air bags recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Rav4, Rav4 Hybrid, and Rav4 Prime vehicles. The front passenger seat may have been assembled with interference between internal parts that may cause the Occupant Classification System (OCS) sensor to incorrectly detect the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence: Incorrect detection of an occupant may result in improper air bag deployment during a crash, increasing the risk of injury.

Remedy per NHTSA (as of 2026-08-27): Dealers will inspect and repair the front passenger seat, as necessary, free of charge.

20V734000NHTSA report received November 2020Model years: 2020

NHTSA campaign 20V734000: Toyota RAV4 air bags recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.

Remedy per NHTSA (as of 2026-08-27): Toyota will notify owners, and dealers will replace the steering column, free of charge.

20V682000NHTSA report received November 2020Model years: 2019–2020

NHTSA campaign 20V682000: Toyota RAV4 fuel system recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy per NHTSA (as of 2026-08-27): Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge.

20V373000NHTSA report received June 2020Model years: 2019–2020

NHTSA campaign 20V373000: Toyota RAV4 steering recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.

Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.

Remedy per NHTSA (as of 2026-08-27): Toyota will notify owners, and dealers will replace the power steering gear box, free of charge.

20V286000NHTSA report received May 2020Model years: 2019–2020

NHTSA campaign 20V286000: Toyota RAV4 suspension recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.

Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.

Remedy per NHTSA (as of 2026-08-27): Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge.

20V064000NHTSA report received February 2020Model years: 2019–2020

NHTSA campaign 20V064000: Toyota RAV4 engine and engine cooling recall

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.

Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.

Remedy per NHTSA (as of 2026-08-27): Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge.

What does a pre-purchase inspection cover on a used Toyota RAV4?

The same full inspection at every tier, at the seller’s location, with a photo-documented report:

Bronze $249 · Silver $349 · Gold $449. Compare Bronze, Silver and Gold. The core inspection is the same at each tier; Silver and Gold add instrumented measurements.

Similar used compact SUVs

Other compact SUVs to weigh against the Toyota RAV4. Recall counts cover different model-year spans and are not a reliability ranking.

What does a pre-purchase inspection not do?

Common questions about buying a used Toyota RAV4

Where can I book a Toyota RAV4 pre-purchase inspection?

Vehicle Inspectors matches buyers with independent inspectors nationwide. Local pages for cities with active inspectors:

Recall data from NHTSA recall records (NHTSA public recalls API), retrieved 2026-08-27. Vehicle Inspectors is not affiliated with Toyota. A recall is not a defect finding on any individual vehicle.

Should you buy a used Toyota RAV4?

Which systems do Toyota RAV4 recalls affect?

What are the most recent NHTSA recall campaigns for the Toyota RAV4?